Thoughts on aluminum flywheel - BMW M5 Forum and M6 Forums
E60 M5 and E61 M5 Touring Discussion 2005- Advertiser's Forum

 
LinkBack Thread Tools Rate Thread Display Modes
post #1 of 5 Old 23rd May 2019, 12:54 AM Thread Starter
Wilbur06
Member, Sport: Off DSC: On (>50 posts)
 
Wilbur06's Avatar
 
Join Date: May 2016
Posts: 85
Thanks: 1
Thanked 1 Time in 1 Post
Garage
Thoughts on aluminum flywheel

I plan to do clutch and flywheel, and found single mass billet aluminum clutch masters flywheel, anyone running this set up? Supposed to be better than the dual mass, safer too haha.

It's just money
Wilbur06 is offline  
Sponsored Links
Advertisement
 
post #2 of 5 Old 23rd May 2019, 01:05 AM
Fiftytwoeighty
M5 Expert (>4000)
 
Fiftytwoeighty's Avatar
 
Join Date: Nov 2009
Location: Huntington Beach (Surf City)
Posts: 5,702
Thanks: 1,132
Thanked 961 Times in 811 Posts
I'm running a cluchmasters single mass steel FW with a FX350 clutch for my 6mt. I love it.

Are you SMG or 6mt? The stack heights are different for the SM and DM FW for the 6mt.

~Woody

///M The ///Most Expensive Letter in the Alphabet
Driving Concepts Competition Racing School
s85 + (afterthought) 6mt =158,000 miles with no RCOD and counting ...just saying...

2007 Dinan S2 e60 m5 6MT Interlagos Blue; DINAN 3.91 Exploded @8x,xxx ; Performance Gearing 3.91 LSD 3 clutch, 30/50 ramps, R&P polished ; ClutchMasters FX350 clutch and LTW single mass FW @157,000 miles, RPi Oil Cooler/Scoops; DINAN High Flow Air Mass Meter/Intake, DINAN TBs, DINAN pulley, DINAN strut, DINAN Monoballs, FastAttack Tune, w/Kung Fu grip!, Einhorn Industries Race Jedders, track pipe, and x-pipe; DINAN Section 3, DINAN LTW 19x9 ET18, 19x10 ET25, Michelin PS4S 275/35/19 and 305/30/19, Macht Schnell 15mm spacers (front); FERODO FRP3000H race pads; StopTech BBK 6/4 380mm/35mm x 380mm/32mm w/SS lines; RDSport F/R sways; CKS coils w/swift springs, -2.0/-2.5 F/R camber; z3 1.9L SSK, with f10 shifter; F/R G1W-H; Uniden R1, remote ALP 2Rx:1Tx, F/R NetRadar DSP, w/GPS and BT. SprintBooster v3; Euro MDM and DSC off. Fluids: Motul 7100 4T 10w60, Redline ShockProof Lightweight 75w140, Castrol SRF, Unicorn Jizz and Wolfpack Blood; Rod bearings replaced at 84,000 and 150,000 miles!!!

1988 e28 m5 STROKER 420bhp 91 octane(Paul Burke s38b39); VAC LTW flywheel; MegaSquirt G2 DME; Euro RestoMod track car: caged, 6 point FIA harness, FIA Sabelt GT-160 seats...AC/heater, interior, sunroof, rear seat delete; Euro Headers, dump valve, and race cats; CAE Ultra shifter; custom Ground Control Coilovers/camber plates; Mason Engineering front/rear strut bars; Brembo 6/4 BBK; 17x8 BBS RK w/Dunlop StarSpec II; undergoing Euro restoration, building the e28 CSL ///Motorsport never built. 5.71lbs/hp

1996 FZJ 80; LOCKED; Factory TRD Supercharger; Expo/Overland/Backcountry Rig; custom sleeper/drawer system, full rock armor, 33"s on 2.5" OME Heavy Lift; Rigid LEDs F/R; 231,000 miles and counting.
2008 Audi A3 S-Line Quattro w/flappy paddles (Mammoth Mountain Commuter)
2000 e39 m5 TiAg (Gone, but not forgotten) sold 7/2014.

The Indys that I trust for all my Beasts' needs: oceansidemotorsports.com my local physician for service
fastattackmotorsports.com because JColley!
einhornindustires because WolfPack!

~I FRACKING!
~Viva La Wolfpack!
Fiftytwoeighty is online now  
post #3 of 5 Old 23rd May 2019, 01:07 AM Thread Starter
Wilbur06
Member, Sport: Off DSC: On (>50 posts)
 
Wilbur06's Avatar
 
Join Date: May 2016
Posts: 85
Thanks: 1
Thanked 1 Time in 1 Post
Garage
Wilbur06 is offline  
 
post #4 of 5 Old 23rd May 2019, 05:42 PM
simonnim
Member, Sport: On DSC: On (>100 posts)
 
simonnim's Avatar
 
Join Date: Jul 2017
Location: California
Posts: 130
Thanks: 9
Thanked 7 Times in 7 Posts
Is there a lot of chatter?

2007 E60 M5 - Indianapolis Red
- Bearings changed at 69,500 with WPC coated 702/703
- RPI scoops & BMC filters
- Charcoal filter delete
- Custom X-pipe
- Resonator Delete
- G-Power section 3
- Gloss black kidney and fender grills
- Euro SMG tune
- ECS stainless steel brake lines
- Castrol SRF brake fluid
simonnim is offline  
post #5 of 5 Old 23rd May 2019, 06:46 PM
Fiftytwoeighty
M5 Expert (>4000)
 
Fiftytwoeighty's Avatar
 
Join Date: Nov 2009
Location: Huntington Beach (Surf City)
Posts: 5,702
Thanks: 1,132
Thanked 961 Times in 811 Posts
Quote:
Originally Posted by simonnim View Post
Is there a lot of chatter?
My SM LTW steel FW has a slight chatter when warm.

Its not as loud as an aluminum FW.

The chatter from mine is barely noticeable in the cabin.

Ive been meaning to do a full review, but Ive been too busy. Ill try to take a quick video later.

~Woody

///M The ///Most Expensive Letter in the Alphabet
Driving Concepts Competition Racing School
s85 + (afterthought) 6mt =158,000 miles with no RCOD and counting ...just saying...

2007 Dinan S2 e60 m5 6MT Interlagos Blue; DINAN 3.91 Exploded @8x,xxx ; Performance Gearing 3.91 LSD 3 clutch, 30/50 ramps, R&P polished ; ClutchMasters FX350 clutch and LTW single mass FW @157,000 miles, RPi Oil Cooler/Scoops; DINAN High Flow Air Mass Meter/Intake, DINAN TBs, DINAN pulley, DINAN strut, DINAN Monoballs, FastAttack Tune, w/Kung Fu grip!, Einhorn Industries Race Jedders, track pipe, and x-pipe; DINAN Section 3, DINAN LTW 19x9 ET18, 19x10 ET25, Michelin PS4S 275/35/19 and 305/30/19, Macht Schnell 15mm spacers (front); FERODO FRP3000H race pads; StopTech BBK 6/4 380mm/35mm x 380mm/32mm w/SS lines; RDSport F/R sways; CKS coils w/swift springs, -2.0/-2.5 F/R camber; z3 1.9L SSK, with f10 shifter; F/R G1W-H; Uniden R1, remote ALP 2Rx:1Tx, F/R NetRadar DSP, w/GPS and BT. SprintBooster v3; Euro MDM and DSC off. Fluids: Motul 7100 4T 10w60, Redline ShockProof Lightweight 75w140, Castrol SRF, Unicorn Jizz and Wolfpack Blood; Rod bearings replaced at 84,000 and 150,000 miles!!!

1988 e28 m5 STROKER 420bhp 91 octane(Paul Burke s38b39); VAC LTW flywheel; MegaSquirt G2 DME; Euro RestoMod track car: caged, 6 point FIA harness, FIA Sabelt GT-160 seats...AC/heater, interior, sunroof, rear seat delete; Euro Headers, dump valve, and race cats; CAE Ultra shifter; custom Ground Control Coilovers/camber plates; Mason Engineering front/rear strut bars; Brembo 6/4 BBK; 17x8 BBS RK w/Dunlop StarSpec II; undergoing Euro restoration, building the e28 CSL ///Motorsport never built. 5.71lbs/hp

1996 FZJ 80; LOCKED; Factory TRD Supercharger; Expo/Overland/Backcountry Rig; custom sleeper/drawer system, full rock armor, 33"s on 2.5" OME Heavy Lift; Rigid LEDs F/R; 231,000 miles and counting.
2008 Audi A3 S-Line Quattro w/flappy paddles (Mammoth Mountain Commuter)
2000 e39 m5 TiAg (Gone, but not forgotten) sold 7/2014.

The Indys that I trust for all my Beasts' needs: oceansidemotorsports.com my local physician for service
fastattackmotorsports.com because JColley!
einhornindustires because WolfPack!

~I FRACKING!
~Viva La Wolfpack!
Fiftytwoeighty is online now  
Reply

Bookmarks

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the BMW M5 Forum and M6 Forums forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in











Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes Rate This Thread
Linear Mode Linear Mode
Rate This Thread:



Similar Threads
Thread Thread Starter Forum Replies Last Post
Pedal Haus E60 M5 Aluminum Pedals - Review/Guide C7mb E60 M5 and E61 M5 Touring Discussion 26 22nd August 2014 04:35 PM
Help Identify Aluminum Flywheel Chris Yates E39 M5 and E52 Z8 Discussion 13 29th June 2010 04:55 AM
New or Used Flywheel? JML M5 E39 M5 and E52 Z8 Discussion 16 28th February 2008 02:45 PM
Modified Lightweight Flywheel EaglEye E39 M5 and E52 Z8 Discussion 2 17th February 2007 06:08 PM
flywheel question (not about aluminum one) DrewKeen E39 M5 and E52 Z8 Discussion 3 4th January 2005 02:39 PM

Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome